MATERIAL SAFETY DATA SHEET

 

SPILFYTER® Products                                                          Page 1 of 5

Battery Acid Wipes                                                                 Revision Date: 07/27/06

MSDS No. BAW1006

 

Section 2. Composition/Information on Ingredients

 

All Cercla Hazardous Ingredients are listed at 1% or greater and carcinogens at 0.1% and greater.

COMPONENTS                                CAS.                                         # PEL:

Dipotassium Salt                               584-08-7                              Not Established

 

Reported As Potenial Carcinogen Or Known Carcinogen:    No

If Yes, Reported By:                  Iarc                     Ntp         Osha

Sara Hazard Categorty:                                No

                       

 

Section 3. Hazards Identification

 

Potential Health Effects:

Primary Routes of Entry into the Body: Skin Absorption:     xx          Inhalation:         Ingestion

Acute Effects:            Eyes: Severely irritating

                        Skin: Irritating

                        Inhalation: Irritation, Coughing

                        Ingestion: Irritating.

Chronic Effects:          Not Known

 

Eye Contact: IMMEDIATELY FLUSH EYES WITH A DIRECT STREAM OF WATER for at least 15 minutes, forcibly holding eyelids apart to ensure complete irrigation of all eye and lid tissue. Washing eyes within several seconds is essential to achieve maximum effectiveness. Get medical attention immediately.

Skin Contact: Wash thoroughly with soap and water for 15 minutes. Remove contaminated clothing. If irritation persists get medical attention at once.

Inhalation: Move victim to fresh air. If symptoms persist seek medical attention.

Ingestion: Do not induce vomiting. Give large quantities of water. Seek immediate medical attention.

 

MATERIAL SAFETY DATA SHEET

 

SPILFYTER® Products                                                          Page 1 of 5

Battery Acid Wipes                                                                 Revision Date: 07/27/06

MSDS No. BAW1006

Flash point - non-flammable

Flammable or explosive limits (approximate percent by volume in air) lel= na uel= na

Extinguishing media: foam ** co2 ** dry chemical ** water/fog ** other

Unusual fire and explosion hazard: na

Special fire fighting procedures: none

Decomposition products under fire conditions: none

“Empty”Container Warning:

Empty containers retain residue (liquid and/or vapor) and can be dangerous. Do not pressurize, cut, weld, braze,

Solder, drill, grind or expose such containers to heat, flame, sparks or other sources of ignition: they may explode

And cause injury or death. Do not attempt to clean since some residue is difficult to remove. “empty” be completely

Drained, properly bunged and properly returned to a drum reconditioner. All other containers should be disposed

Of in a environmentally safe manner and in accordance with governmental regulations.

 

Avoid breathing vapors. Avoid contact with skin, eyes, or clothing. Contain the spill and collect the material using chemically resistant sorbent products. If this product is mixed with other materials, see Section 13.

 

Section 7. Handling and Storage

Storage: Store In A Cool Dry Place.

Handling: It Is Always Good Practice To Wear Rubber Gloves, Rubber Boots, Rubber Apron And Splash

Goggles When Using Any Cleaning Compound.

Precautionary Labeling: None Under Normal Use.

      Exposure Limits: Triethanolamine

            ACGIH TLV is 5 mg/M³.

                  OSHA PEL: Not Established

 

The end-user must determine the specific types of personal protective equipment needed according to 29 CFR 1910.132—Personal Protective Equipment (PPE) for General Industry. The following are only suggestions:

·   Eyes: Safety glasses, goggles, or face shield

·   Skin: Suitable chemically resistant gloves and protective clothing

·   Inhalation: Air purifying respirator with appropriate chemical cartridge or canister

Section 9. Physical and Chemical Properties

Boiling Range: 228-237 F Ph: 11       Percent Volatile: Na Specific Gravity: 1.2 -1.3

Vapor Density: Not Determined         Solubility: Complete In Water

Appearance: Clear Colorless Liquid           Odor: Unscented

                                                                 

 

MATERIAL SAFETY DATA SHEET

 

SPILFYTER® Products                                                          Page 1 of 5

Battery Acid Wipes                                                                 Revision Date: 07/27/06

MSDS No. BAW1006

Conditions Contributing To Instability: Under Normal Conditions, This Product Is Stable.

Incompatibility: Acids

Hazardous Decomposition: None

Conditions Contributing To Hazardous Polymerization: Material Is Not Known To Polymerize.

Corrosive Action On Materials: None Under Normal Conditions.

 

Section 12. Ecological Information

 

Section 13. Disposal Considerations

 

Waste Disposal Method: Treat Or Dispose Of According To Regulations Under The Resource

Conservation And Recovery Act As Administered By The Usepa Or Appropriate State Agency.

 

U.S. Dept. Of Transportation: Not Regulated

Canadian T.D.G.: Class D2b

Section 15. Regulatory Information

 

SARA; SECTION 313 (Toxic Chemical Release Reporting) 40 CFR 372 - None of the ingredients are listed

Toxic Substances Control Act (TSCA): All the ingredients are listed on the Chemical Substance Inventory

State/Int’l Right-to-Know Regulations: Canada’s WHMIS: Potassium 10pH.

 

 

 

 

 

 

 

 

 

MATERIAL SAFETY DATA SHEET

 

SPILFYTER® Products                                                          Page 1 of 5

Battery Acid Wipes                                                                 Revision Date: 07/27/06

MSDS No. BAW1006

 

      Abbreviations:

            CFR: Code of Federal Regulations

            OSHA: Occupational Safety and Health Administration

            MSDS: Material Safety Data Sheet

            PEL: Permissible Exposure Limit

            NA: Not Applicable

            ACGIH: American Conference of Governmental Industrial Hygienists

            TLV: Threshold Limit Value

            NTP: National Toxicology Program

            IARC: International Agency for Research on Cancer

            RCRA: Resource Conservation and Recovery Act

            TSCA: Toxic Substances Control Act

            SARA: Superfund Amendments and Reauthorization Act

            USEPA: United States Environmental Protection Agency

            CERCLA: Comprehensive Response, Compensation, and Liability Act

            DOT: Department of Transportation

      WHMIS: Workplace Hazardous Materials Information System

      n.o.s.: Not Otherwise Specified

            NFPA: National Fire Protection Association

      HMIS: Hazardous Material Information System

 

NFPA Ratings:                                    HMIS Ratings:

      Health: 1                                       Health: 1

      Fire: 1                                          Flammability: 1

      Reactivity: 0                                          Reactivity: 0

      Special Hazard: None                             Personal Protection: X

 

NOTE: This MSDS has been prepared only for the KOLORESAFE® Liquid Acid Neutralizer (4100 Series) of SPILFYTER® Products. The MSDS’s of the chemicals used with this product must be reviewed completely, and precautions taken as described.

 

The information accumulated herein has been compiled from sources believed to be reliable and is accurate to the best of our knowledge. However, NPS Corporation cannot give guarantees regarding the information from sources, and expressly does not make any warranties, nor assumes any liability for its uses of this product.

 

Disclaimer

You have purchased SPILFYTER® products from NPS Corporation

You have been provided data, product labels, MSDS’s, and other information about SPILFYTER® Products.

 

Some SPILFYTER® Products are hazardous. Information about SPILFYTER® Products that are hazardous is furnished without guarantee. NPS Corporation does not guarantee the accuracy of the information about hazardous SPILFYTER® Products.

 

Those products are only to be used by people having expertise in using the hazardous products.

 

MATERIAL SAFETY DATA SHEET

 

SPILFYTER® Products                                                          Page 5 of 5

KOLORSAFE® Liquid Acid Neutralizer                                                  Revision Date: 07/19/05

MSDS No. 1006

 

 

No guarantee, expressed or implied, is made by NPS Corporation about the results of use of its products. No guarantee is made as to the safety and toxicity of any SPILFYTER® Product.

 

NPS Corporation does not assume any liability arising out of use of SPILFYTER® Products. Additional information and research may be necessary before you use the SPILFYTER® Products. NPS Corporation is not responsible for damages, direct or indirect, resulting from the use of SPILFYTER® Products or from reliance on data in the MSDS or product label.

 

If you resell SPILFYTER® Products, you must, by law, furnish your customers a copy of MSDS’s and handling instructions.

 

You are also required by law to insure that all SPILFYTER® Products are properly shipped.